Batteries

by Debra Fiakas CFA The series on graphite resource development is completed with a discussion of the companies that are currently in production.  The U.S. Geological Survey estimates 1.2 million metric tons of flake graphite are produced annually.  The vast majority  -  780,000 metric tons  -  are produced in China.  India and Brazil follow with 170,000 metric tons and 80,000 metric tons, respectively.  North America, which seems to show so much promise to the graphite resource developers that have been featured over the past few articles, is currently only contributing 30,000 metric tons per year to the graphite...

John Petersen In late June I wrote a forward looking article that identified several companies in my energy storage and vehicle electrification group that I expected to perform well or perform poorly during the third quarter. Since short-term market changes are notoriously hard to predict, it’s worthwhile to look back and see where I got things right and where I got them wrong. So I’ll start today with a quick summary table and assess the relative accuracy of my Q3 calls, and then turn my attention to Q4, which is shaping up as a time of bright opportunity...

John Petersen Last week Johnson Controls (JCI) released the results of a nationwide survey that found that 97 percent of Americans are ready for micro-hybrids with stop-start idle elimination, the most sensible automotive innovation in years. A micro-hybrid turns the engine off to save fuel and eliminate exhaust emissions when it's stopped in traffic and automatically restarts the engine when necessary. While the overwhelmingly positive consumer response didn't surprise me, JCI's short-term growth forecast for micro-hybrids did. I've been writing about the rapidly evolving micro-hybrid space since 2008 and during that time the market penetration forecasts have...

by Debra Fiakas CFA The market for lithium ion batteries is expected to reach $46 billion by 2022.  That represents 11% compound annual growth over the next six years.  Few other markets if any are growing at such a feverish pace.  The adoption of electric cars is the center of the excitement, but the proliferation of smartphones, tablets and other electronic devices also plays a part.  Suppliers of critical battery materials such as lithium, cobalt and graphite are salivating over potential sales to battery manufacturers. Graphite with its strong conductivity and heat-resistant qualities is a perfect material...

John Petersen The next couple months are shaping up as a time of extraordinary change in the energy storage sector. Events that will drive the change include: Press reports indicate that the Department of Energy will be ready to announce it's preliminary decisions on the allocation of $2 billion in ARRA battery manufacturing grants sometime this week; We've seen numerous reports on automaker's plans to begin manufacturing PHEVs and EVs in limited volumes for testing and demonstration purposes; New tailpipe emission standards in Europe and accelerated CAFE standards...

Green money managers' stock picks after the Japanese nuclear crisis. Even as the nuclear disaster in Japan unfolds, it's clear that the world's energy industry will be forever changed. Russian reactors were never considered safe, but a Japanese to have a nuclear meltdown is an entirely different story. Market Reaction Since Monday, nuclear stocks and ETFs have been plummeting. As of Wednesday night, The Market Vectors Uranium + Nuclear Energy ETF (NYSE:NLR), the iShares S&P Global Nuclear Energy Index (NASD:NUCL), PowerShares Global Nuclear Energy Portfolio ETF (NYSE:PKN), and the Global X Uranium ETF (NYSE:URA) are down...

John Petersen Last Friday President Obama and executives from thirteen leading automakers gathered in Washington DC to announce an historic agreement to increase fleet-wide fuel economy standards for new cars and light trucks from 27.5 mpg for the 2011 model year to 54.5 mpg for the 2025 model year. While politicians frequently spin superlatives to describe mediocre results, I believe the President's claim that the accord "represents the single most important step we've ever taken as a nation to reduce our dependence on foreign oil" is a refreshing example of political understatement. After three decades of demagoguery, debate,...

The Economist had two great articles last week on two of may favorite themes in renewable energy, which I missed getting to Charles in time for  The Week in Cleantech.  Both deal with modernizing the grid to deal with the vagaries of wind.  The first is an in depth look at electricity transmission via High Voltage DC, a subject I recently wrote about in an article on ABB.  The second dealt with compressed air energy storage (CAES) which is the second cheapest way to store electricity, after pumped hydro.  Unfortunately, I have not found good ways for the stock...

America’s electric power grid is subject to immense inefficiencies that arise from the interplay between centralized power generation, local power consumption and on demand utility service. To put things into a broad perspective, the nameplate capacity of U.S. generating facilities is about 1 million Megawatts (MW), so if all of our power plants ran 24/7 we would have a theoretical annual generating capacity of 8.7 billion Megawatt-hours (MWh). Since demand for electricity fluctuates on both a daily and seasonal basis, total electric power generation in 2007 was only 4.2 billion MWh, or less than 50% of nameplate...

Jason HamlinThe lithium market is buzzing as GM, Nissan and other car manufacturers get set to roll out a new series of electric cars that will greatly increase demand for the obscure silver-white alkai metal. GM has announced plans to construct a $43 million plant in Michigan to build lithium-ion batteries for its Chevrolet Volt electric-powered car, which captured headlines with its claim of 230 miles per gallon. Adding to the lithium mania is Washington’s support in the form of $2 Billion in stimulus funding: “New plug-in hybrids roll off our assembly lines, but they will run...

John Petersen I was recently invited to prepare a memorandum on the battery industry for the electric mobility working group of the World Energy Council, a global thought leadership forum established in 1923 that includes 93 national committees representing over 3,000 member organizations including governments, businesses and research institutions. Since my memorandum integrated several themes from this blog and tied them all together, I've decided to publish a lightly edited version for readers. To set the stage for the substantive discussion that follows, I’ll start with an 1883 quote from Thomas Edison: “The storage battery is one...

John Petersen Generation specific cultural references can be treacherous ground for bloggers because the flashback effect is usually limited to readers with long and vivid memories. In this case, however, the lessons of history are so relevant that I'll accept the risk and offer some context for younger readers. In my youth a war wrapped in the liberal ideology of the Kennedy and Johnson administrations and fueled by an underlying concern over who would control oil and gas resources in the Gulf of Tonkin was fought in the jungles of Vietnam, Laos and Cambodia. By current standards,...

John Petersen In 1883 Thomas Edison said, "The storage battery is one of those peculiar things which appeals to the imagination, and no more perfect thing could be desired by stock swindlers than that very selfsame thing. ... Just as soon as a man gets working on the secondary battery it brings out his latent capacity for lying." The problem isn't so much the batteries, which haven't improved all that much over the last century. Instead, the problem lies in the fertile imaginations of scientists, engineers, politicians, ideologues, analysts and investors who focus on new energy...

John Petersen In late October I gave a keynote presentation at Batteries 2012, one of the largest lithium-ion battery conferences in the world. During the conference, I was buttonholed for a couple hours by the chairman's global strategy team for one of the top three lithium-ion battery manufacturers in the world. They started by explaining that their Global 100 company is abandoning the plug-in vehicle market to focus on sensible applications where it can earn a reasonable margin. Then they started drilling down with a series of detailed and probing questions about whether any of the principal lead-acid...

John Petersen I'm a cynic and a heretic when it comes to plug-in vehicle schemes because most defy the laws of economic gravity and violate a cardinal rule that Ford engineers developed for the EcoStar light delivery vehicle program in the early '90s: – The unloaded weight of a plug-in vehicle should never exceed 70% of its loaded weight. Investors who pay attention to this simple rule can easily distinguish between pipe-dream vehicle electrification schemes that are nothing more than feel-good eco-bling and realistic vehicle electrification projects that make economic sense. For the last...

John Petersen Albert Einstein once said, "If you can't explain it simply, you don't understand it well enough." So when the editor of Batteries International asked if I could present my analysis of plug-in vehicles in two pages and prove my numbers in a way that any open-minded adult could follow, understand and verify with an Internet search engine, I jumped at the challenge. The article was published yesterday in their Winter Edition. Since the numbers have profound implications for the energy storage sector and an expected flurry of ill-conceived electric vehicle projects like the planned Tesla Motors...